IBM S30 Manual de usuario

ThinkPad s30, s31 HardwareMaintenance Manual򔻐򗗠򙳰

Symbol Color Meaning(1) Battery statusGreen Enough battery powerremains for operation.BlinkingorangeThe battery pack needs tobe charged.Orange The bat

Related service informationThis section provides information about restoring thepre-installed software.Restoring the pre-installed softwareTo restore

3. A menu will appear stating ″Your computer originallyincluded a Product Recovery program...Reinstall theProduct Recovery Program? (Y/N)″.Note: If th

3. At the prompt, press F11. (The option to press F11appears for only a few seconds. You must press F11quickly). The Product Recovery program main men

Symptoms (Verified) Go toPower failure. (The power-onindicator does not go on or stayon.)“Power System Checkout” onpage 14, then use table in“Power-Re

Note: The pull-down menu differs depending on themodel.4. Run the applicable function test.5. Follow the instructions on the screen. If there is aprob

If the distance between the Access Point and thesystem is too far, the test may report failure even ifthe device is properly working. If the encryptio

1. Replace the keyboard.2. Replace the system board.The following auxiliary input devices are supported for thiscomputer:v Numeric keypadv Mouse (USB-

1. Boot from the diagnostics diskette and start theprogram.2. Go to Diagnostics on the main menu and select OtherDevices.3. Follow the description in

If the voltage is within the range, do the following:v Replace the system board.v If the problem is not corrected, go to “UndeterminedProblems” on pag

Before using this information and the product it supports,be sure to read the general information under “Read ThisFirst” on page 1.Second Edition (Oct

3. If the voltage is less than 10.6V, the battery ASM hasbeen discharged, recharge the battery ASM. If thevoltage is still less than 10.6V, replace th

Suspend ModeIn suspend mode, the following occurs:v The LCD is powered off.v The hard disk drive is powered off.v The CPU stops.Events that cause the

The computer exits hibernation mode and resumesoperation when the power-on switch is pressed. Whenpower is turned on, the hibernation file in the boot

Symptom-to-FRU IndexThe Symptom-to-FRU Index lists the symptoms and errorsand the possible causes. The most likely cause is listedfirst.Note: Perform

Symptom/Error FRU/Action in Sequence0212KeyboardController FailedGo to “Keyboard and Auxiliary Input DeviceCheckout” on page 12.0213Keyboard locked— U

Symptom/Error FRU/Action in Sequence0281Memory sizefound by POSTdiffered fromCMOS1. Load Setup Defaults in the BIOS SetupUtility.2. DIMM3. System boar

Symptom/Error FRU/Action in SequenceOperating systemnot found1. Check that the operating system has nofailure and is installed correctly.2. Enter IBM

Keyboard-Related SymptomsSymptom/Error FRU/Action in SequenceKeyboard (one or morekeys) doesn’t work.1. Reseat the keyboard cable.2. Keyboard3. System

Speaker-Related SymptomsSymptom/Error FRU/Action in SequenceSpeakers make noise orno sound comes fromsystem.1. Speakers2. System boardIn DOS or Window

Symptom/Error FRU/Action in SequenceIEEE 1394 does not workcorrectly1. IEEE 1394 cable2. Card-to-system board cable3. IEEE 1394/LAN card ASM4. System

ContentsThinkPad s30, s31 Hardware Maintenance Manual 1Read This First ...1What to Do First ...2How to Disable the Password ...3

Verify that the power supply being used at the time of thefailure is operating correctly. (See “Power SystemCheckout” on page 14.)1. Power off the com

CE Utility Program DisketteWriting the Serialization InformationThe EEPROM on the system board contains theSerialization Information Data— that is, a

FRU Removals and ReplacementsThis section contains information about removals andreplacements.v Do not damage any parts. Only certified and trainedper

LCD FRU Replacement NoticeThe TFT LCD (XGA 10.4–inch) for the computer containsmany thin-film transistors (TFTs). A small number ofmissing, discolored

1010 Battery ASMTo remove the battery ASM:1. Slide the release latch as shown.2. Remove the battery ASM.Reverse the steps described above when install

1020 Keyboard ASMv 1010 Battery ASMTo remove the keyboard ASM:1. Remove the four screws securing the keyboard.2. Loosen the other three screws: these

1030 Hard Disk Drive ASMv 1010 Battery ASMv 1020 Keyboard ASMWarning:v Do not drop or apply any shock to the hard disk drive.The hard disk drive is se

2. Disconnect the IDE connector from the system boardand remove the hard disk drive.For the s31 seriesTo remove the hard disk drive ASM:1. Slide and l

3. Remove the HDD/FPC bracket.4. Disconnect the IDE connector from the system boardand remove the hard disk drive.StepSize(Quantity) Head & Color

1035 Hard Disk Drive FPC ASMv 1010 Battery ASMv 1020 Keyboard ASMv 1030 Hard Disk Drive ASMWarning:v Do not drop or apply any shock to the hard disk d

1055 Modem Cable ASM ...391060 Wireless Card ASM (s30 only) ...401065 IEEE 1394/LAN Card ASM ...411070 IEEE 1394/LAN Card Cable ASM ...4210

1040 Suspend Board ASMv 1010 Battery ASMv 1020 Keyboard ASMTo remove the suspend board:1. Disconnect the cable from the suspend board.2. Remove the tw

1045 Suspend Board Cable ASMv 1010 Battery ASMv 1020 Keyboard ASMv 1040 Suspend Board ASMTo remove the suspend board cable ASM:v Disconnect the suspen

1050 Modem Card ASMv 1010 Battery ASMv 1020 Keyboard ASMTo remove the modem card ASM:1. Remove the two screws.2. Lift the modem card to disconnect it

1055 Modem Cable ASMv 1010 Battery ASMv 1020 Keyboard ASMv 1050 Modem Card ASMTo remove the modem cable ASM:v Disconnect the modem cable from the syst

1060 Wireless Card ASM (s30 only)v 1010 Battery ASMv 1020 Keyboard ASMWarning:Special care must be taken when disconnecting theantenna cables from the

1065 IEEE 1394/LAN Card ASMv 1010 Battery ASMv 1020 Keyboard ASMTo remove the IEEE 1394/LAN card ASM:1. Disconnect the IEE 1394 cable from the card.2.

1070 IEEE 1394/LAN Card Cable ASMv 1010 Battery ASMv 1020 Keyboard ASMv 1065 IEEE 1394/LAN Card ASMv 1040 Suspend Board ASMTo remove the IEEE 1394/LAN

1075 DIMM Card ASMv 1010 Battery ASMv 1020 Keyboard ASMTo remove the memory card ASM:1. Carefully release the latches on both sides of thememory card.

1080 Upper Cover ASMv 1010 Battery ASMv 1020 Keyboard ASMTo remove the upper cover ASM:1. Remove the two screws.A2. Turn the computer over, then remov

1085 Speaker ASMv 1010 Battery ASMv 1020 Keyboard ASMTo remove the speakers ASM:1. Remove the connector.2. Remove the four screws securing the speaker

ThinkPad s30, s31 HardwareMaintenance ManualAbout This ManualThis manual contains service and reference information forthe IBM ThinkPad s30 and s31pro

1090 Palm Rest ASMv 1010 Battery ASMv 1020 Keyboard ASMv 1085 Speaker ASMTo remove the palm rest ASM:1. Remove the three screws.2. Remove the palm res

1100 Fan ASMv 1010 Battery ASMv 1020 Keyboard ASMWarning:Do not apply pressure on the fan blades or hub assembly;doing so can damage the fan bearings.

Thermal rubberProtective paperStepSize(Quantity) Head & Color Torque1 M2.0 x 7L (3) Flat head, black 2.5 kgf-cm1A M2.0 x 9L (1) Flat head, black 2

1130 PCMCIA Slotsv 1010 Battery ASMv 1020 Keyboard ASMv 1100 Fan ASMWarning:Special care must be taken when disconnecting thePCMCIA slots not to cause

3. Remove the HDD/FPC bracket.4. Disconnect the FPC connector from the system board.5. Grip firmly at the sides of the PCMCIA slots, then lift upto re

1140 System Boardv 1010 Battery ASMv 1020 Keyboard ASMv 1030 Hard Disk Drive ASMv 1040 Suspend Board ASMv 1045 Suspend Board Cable ASMv 1050 Modem Car

1145 Power Board ASMv 1010 Battery ASMv 1020 Keyboard ASMv 1030 Hard Disk Drive ASMv 1040 Suspend Board ASMv 1050 Modem Card ASMv 1060 Wireless Card A

1150 LCD Bezel ASMv 1010 Battery ASMTo remove the LCD bezel ASM:1. Remove the screw cap covers.2. Remove the four screws as shown.3. Gripping as shown

1155 LCD Rear Cover ASMv 1010 Battery ASMv 1150 LCD Bezel ASMTo remove the LCD rear cover ASM:1. Remove the two screws from the rear cover as shown.2.

1160 LCD Inverter ASMv 1010 Battery ASMv 1150 LCD Bezel ASMv 1155 LCD Rear Cover ASMTo remove the LCD inverter ASM:1. Disconnect the flex cable from t

this is suspected, clear the error log and run the testagain. Do not replace any FRUs if log errors do notreappear.Be careful not to replace a non-def

1170 LCD FPC ASMv 1010 Battery ASMv 1020 Keyboard ASMv 1080 Upper Cover ASMv 1150 LCD Bezel ASMv 1155 LCD Rear Cover ASMTo remove the LCD FPC ASM:Note

4. Remove the tape from the FPC cable.5. Lift the two sides of the FPC connector as shown.6. Disconect the FPC cable from the inverter card.7. Disconn

1180 LCD Panel ASMv 1010 Battery ASMv 1020 Keyboard ASMv 1080 Upper Cover ASMv 1150 LCD Bezel ASMv 1155 LCD Rear Cover ASMv 1160 LCD Inverter ASMv 117

1185 Hinge ASMv 1010 Battery ASMv 1020 Keyboard ASMv 1080 Upper Cover ASMv 1150 LCD Bezel ASMv 1155 LCD Rear Cover ASMv 1160 LCD Inverter ASMv 1170 LC

StepSize(Quantity) Head & Color Torque1 M2.5 x 5L (3) Flat head, black 2.5 kgf-cmNote: Make sure you use the correct screw for replacement.60 Thin

1190 Hinge ASM (Wireless—s30 only)v 1010 Battery ASMv 1020 Keyboard ASMv 1080 Upper Cover ASMv 1150 LCD Bezel ASMv 1155 LCD Rear Cover ASMv 1160 LCD I

4. Disconnect the cables from the wireless card.StepSize(Quantity) Head & Color Torque1 M2.5 x 5L (3) Flat head, black 2.5 kgf-cmNote: Make sure y

1195 Base ASMv 1010 Battery ASMv 1020 Keyboard ASMv 1030 Hard Disk Drive ASMv 1040 Suspend Board ASMv 1050 Modem Card ASMv 1080 Upper Cover ASMv 1060

Computer Parts ListingFor s30 and s31abcdNote: Each FRU is available for all types or models,unless specific types or models are given.Index Descripti

Index Description FRUNumber3 KEYBOARD ASM 02K5916KEYBOARD ASM (i-Series) 02K5923KEYBOARD ASM US for s31 02K5917KEYBOARD ASM Traditional Chinesefor s31

v Sticky keys caused by spilling liquid onto the keyboardThe following symptoms might indicate damage caused bynon-warranted activities:v Missing part

Description FRU Number9-CELL BATTERY for s30 02K68029-CELL BATTERY for s31 02K6893POWER CORD (Japan 2 PIN) 13H5273CABLE PACK (RJ-11 cable, suspend boa

LCD Unit Parts ListingfgehIndex Computer FRUNumbere — h See MISC PARTS list 26P92991 LCD BEZEL ASM 26P9303LCD BEZEL ASM (i-Series) 26P95092 HINGE-R w/

Service ToolsDescription FRU No.Diagnostic Diskette N/ACE Utility Diskette N/ARecovery CD Japan Win2K for s30 (2639-4WJ,42J)46P4410Recovery CD Japan W

NoticesReferences in this publication to IBM products, programs,or services do not imply that IBM intends to make theseavailable in all countries in w

Product OverviewThe following shows an overview of the system features ofthe ThinkPad s30 and s31 series.Feature DescriptionProcessor Intel Mobile Pen

Fn + ResultF4 Suspend modeF7 Switch between the LCD, the external monitor, andboth the LCD and external monitor.F12 Hibernation modeInsert Increases t